- Extruded aluminium, stainless fixings
- Powder-coated, anodised or woodgrain
- Sectional, tip-up or roll-up slat
An aluminium garage door is light, does not rust, and takes a finish well. In Benoni that middle point carries more weight than usual: in a town built around water, a material that simply does not corrode is worth a look before anything else.
Aluminium garage doors we supply in Benoni
- Aluminium sectional doors in flush, ribbed and slatted profiles.
- Glazed aluminium doors with full or partial glazing panels.
- Aluminium roll-up doors for low-headroom garages.
- Anodised and powder-coated finishes in a wide colour range.
Why aluminium suits lakeside Benoni
On the streets around Homestead Lake, Rynfield Dam, Kleinfontein and Lakefield, humidity does the damage that no amount of maintenance fully prevents on a steel door. Aluminium removes that failure mode entirely from the panel, and the finish keeps looking right with very little attention. The hardware still needs specifying properly, but the door itself stops being the problem.
Weight and what it saves
A lighter door loads its balance components and its operator less, which means smaller motors, longer hardware life and quieter operation. On a wide double that difference adds up over years of daily cycles.
Glazing and daylight
Aluminium sections carry glazing well, and a glazed upper row turns a dark garage into a usable space. Obscured, tinted and clear glazing are all available, and we show the options rather than describing them.
Insulation, and the honest limitation
Bare aluminium conducts heat readily, so a single-skin aluminium door is not an insulated door. Where the garage is used as a room we fit an insulated core with an aluminium face and quote it as what it is. We would rather sell the right product than defend the wrong one later.
Strength and hail resistance on wide openings
Aluminium is lighter than steel and needs more section to reach the same stiffness. On wide double openings, and on doors exposed to East Rand hail, we specify a heavier profile or a reinforced section rather than letting the door flex, because flex is what makes a wide door track badly and a thin face dent.
Matching aluminium window frames
Most housing built here in the last twenty-five years has aluminium window frames in charcoal, bronze or white. A garage door in the same finish reads as part of the building rather than as an addition.
What an aluminium garage door costs in Benoni
More than steel and less than timber, with lower running costs than either, and on a damp position it is frequently the cheapest door over ten years. Priced on opening size, profile, glazing, finish and automation.
Common questions
About aluminium garage doors
On the coast, yes — it removes rust as a failure mode entirely. Inland it comes down to weight and looks: lighter doors are easier on the motor and springs, and aluminium is what makes a full-view glazed door possible. Inland, on a budget, coated steel is honest value.
A single-skin one does, and it will radiate into the garage. Where the garage is attached to living space or has been converted, we specify foam-filled aluminium sections with a thermal break, which performs close to an insulated steel sectional.
Wash the face with clean water and mild detergent two to four times a year, more often at the coast, and rinse out the tracks and bottom seal while you are there. No repainting, no rust treatment, no annual reseal.
Yes. A woodgrain sublimation finish gives a convincing timber appearance with none of the recoating. It is what we usually recommend for rental properties and for doors in full sun where nobody will maintain real timber.
Related
Also worth a look
Side-Hinged Garage Doors
Two leaves, nothing overhead
Side-hinged garage doors swing outward on two leaves, like an oversized pair of gates. They suit workshops, storerooms and low garages where nothing can run overhead.
- Steel, timber or aluminium leaves
- Welded steel subframe, adjustable hinges
- No headroom required
Sliding Garage Doors
Where there is no headroom at all
Sliding doors run sideways along the wall instead of upward. The answer when a garage has no usable headroom and a roll-up or sectional door will…
- Runs sideways along the wall
- Manual or motorised
- Suits low-roof and basement garages
Galvanised Roller Shutter Doors
Hot-dip galvanised roller shutter doors that resist rust in coastal and washdown environments. Manufactured to your opening at our Benoni works.